2009 Vactor HXX Vacuum Excavator

STANDARD EQUIPMENT
Hydro-Excavator Standard Module

Debris Body
12 Cubic yard volumetric debris body
Cylindrical design, 1/4" abrasion & corrosion resistant Ex-Ten steel
Flat style, 3/4 rear door, hinged at top w/replaceable neoprene seal
Hydraulic rear door locking system with door grabber
Hydraulic rear door open & close system
6" Knife valve with 10' drain hose, cam-loc connector
8" Inspection port, Top mounted with ladder for easy access
Rear door support for operator safety
Font mounted hydraulic dump cylinder, 50 degree dump angle, power up/power down
Dual air ports with dual 10" stainless steel float ball shutoff system/stainless steel screens

Water Tanks
1300 Gallon capacity - #304 3/16" stainless steel water tank
Water tank separate from debris tank
Includes anti-siphon device & anti-splash valve w/25' water fill hose and connectors
Water level sight gauge, Mark III electronic low water warning system
10 Year warranty against corrosion and cracking

Water System
Water system rated design is 20 gpm @ 2500 psi
Hydraulic operated Tri-plex piston water pump
Water pump on/off located on pendant control and control box
Variable pressure and flow achieved by electronic-over-hydraulic controls at operators station
Handgun hose 3/8" x 75' w/operating pressure of 3500 psi and burst pressure of 14,500 psi, located in heated cabinet.

PD Vacuum System
Hibon 8702 Tri-Lobe ( 28" HG ) 5150 CFM @ Max. Speed 2000 RPM
Ultra Quiet Inlet and Outlet Silencers Acoustically Matched to Blower
Direct Drive Omsi Transfer Case
Dual Cyclonic Separators with 12" clean out door
Microstrainer Final Filter with 3" Camlock drain
Vacuum relief located in the inlet of debris tank to allow operator to vent to atmosphere. Pendant control operated.
Remote push button pendant control w/75' cable with a vacuum relief, water on/off and throttle control

Control Panel (Located Passengers Side)
Located inside an aluminum box for protection
The control panel will include:Chassis Engine tachometer w/hourmeter, Blower tachometer,Blower temperture gauge, Mark III electronic low water indicator, circuit breakers, water pump on/off, Vacuum gauge, water pump pressure control
Joystick boom control at operator's station

Boom & Vacuum Hose
7' Hydraulic extendable boom/top mounted with 320 degrees of rotation
8" I.D. wire reinforced rubber suction hose
Boom will have an electric-over-hydraulic solenoid system with speed flow control valves
Boom will be powered hydraulically up/down/right/left/extend/retract
Boom control, joystick and hand carried pendant control w/75' cable located at operator station
All boom inlet hose and tubing will be 8" inside diameter

Vacuum Pipe Package
Package will be 1- 8" x 7' aluminum fluidizer tube w/rubber safety end; 2 - 8" x 5 aluminum flanged pipe; 1 - 8" x 7' aluminum flanged pipe; 4 - 8" quick clamps
All connections between debris body and vacuum system will be self-adjusting, pressure fitting type

Water System/Pipe Package
Includes 1 - Digging wand, 1 - dual nozzle assembly, 1 - triple nozzle assenbly, quick couplers and shut-off valve, 3 - Extension pipe assemblies totaling 20 Ft.

Water Heater
Water heater will be rated at 940,000 B.T.U.
12 Volt heater will have no flow/burner shutdown, electronic temperature control, heater inlet pressure gauge, LED temperature display

Hydraulic System
Hydraulic reservoir capacity of 50 gallons w/strainers on all suction lines.
Oil level sight gauge
Inspection hatch for maintenance
10 micron spin on type filter

Electrical
Entire system will be moisture and vapor sealed
Electrical connections require no exposure wires or terminals
Light bulbs will be shock mounted
Complete wiring diagram is provided with machine, circuit breakers are supplied

Storage Cabinets
1 - 50" x 30" deep x 24" high aluminum tool box located right behind cab/water pump and hose retractable handgun reel will be located in this box, box will be heated.

Mounting
Approved truck chassis


Miscellaneous
Tow hooks front and rear
Mud Flaps
Electronic back-up alarm
Fenders

Debris Body
Rear Door Splash Shield
4" Sludge Pump System ( Rear Door Mounted )

Water Tank Accessories
Air Purge System Utilizing Chassis Air System
940,000 BTU water heater Includes: inverter and chassis must have minimum 160 amp alternator
Cabinet Heater, Drain valve donut heater and Insulation Package

Boom Accessories
8 FT. Hydraulic Telescopic Boom W/180 Deg. Rotation

High Pressure Water Pump
12 GPM Cold Weather Recirculation System Front Crankshaft Driven (Manual Trans. Chassis) Chassis Will Require Front Crank Provision.

Hose Reel Accessories
Hydraulic Tool Package

Front Station And Controls
Second operator station: Includes additional hosereel rear mounted with second handgun, plumbing & fittings

Light Accessories
Revolving Light Rear Mounted
Revolving Light Front Mounted
Work Light At Operators Station (One Only)

Tool Box - Vactor & Chassis Accessories
104" X LONG X 24" Deep X 24" High Aluminum Tool Box

Paint
Module - Imron
BODY COLOR: White
CAB COLOR: White
Accessories


Engine “Regeneration Mode” Warning System

Chassis
International 7600 6X4 430HP Manual Trans (PD)